Carl200sx
03/02/2005, 09h32
Oil filter 15208-H8911 Ryco Z145A
Exhaust manifold gasket 14036-D4200 (EXA 1.8, S13 CA18) Four separate pieces
Intake manifold gasket 14035-D5710 (CA18 all) Injector rail to cylinder head
Intake manifold gasket 14035-D5711 (CA18 all) Injector rail to intake runner
Intake manifold gasket 14035-53J10 (SR20 all)
Turbo inlet flange gasket 14415-75F10 (200SX)
or 14415-17M00 (S13 all) The Aust 200SX one fits.
Turbo outlet flange gasket 14445-26E00 (S13 all)
Engine front oil seal 13042-42L00 (CA18 all)
Engine rear oil seal 12279-18V00 (CA18 all)
Oil pan seal front 11121-01F10 (CA18 all)
Oil pan seal rear 11121-01F15 (CA18 all)
Head gasket 11044-51E00 (CA18 all)
Head gasket 11044-50F00 (SR20) until 9/92
Head gasket 11044-50F01 (SR20) from 9/92 till 7/93
Head gasket 11044-50F10 (SR20) from7/93 onwards
Engine gasket kit 10101-51E25 (CA18D) Engine rebuild gasket kits
Engine gasket kit 10101-56E25 (CA18DET)
Engine gasket kit 10101-50E25 (SR20DET)
Engine gasket kit 10101-51E26 (SR20D)
Valve grind gasket kit 11042-51E25 (CA18 all)
Valve grind gasket kit 11042-50F25 (SR20 all)
Fan belt 11720-V7301 (CA18 all) L = 855mm
Fan belt 11720-52F00 (SR20 all)
Compressor belt 11920-V7301 (CA18 all) also suits power steering pump
Compressor belt 11920-30R10 (SR20 all) also suits power steering pump
Water pump 21010-V5528 (CA18) until 8/90
Water pump 21010-V5529 (CA18) from 8/90
Water pump 21010-52F00 (SR20 all)
Thermostat 21200-V0201 (CA18 all) 82.0 C
Thermostat 21200-V0206 (CA18 all) 88.0 C
Thermostat 21200-53J00 (SR20 all)
Radiator cap 21430-01F01
Radiator hose - upper 21501-35F10 (CA18 all)
Radiator hose - lower 21503-35F00 (CA18 all)
Radiator hose - upper 21501-52F00 (SR20 all)
Radiator hose - lower 21503-52F00 (SR20 all)
Engine coolant 10120-89904 Castrol
Fuel filter 16400-F5100 (CA18 and SR20) RYCO Z202
Air Filter 16546-V0100 (same as R31 Skyline) K&N high flow reusable type P/N 33-2031-1
Spark plugs 22401-58S16 (PFR6A11, CA18) Non resistor type NGK BCP6ES11 (11 = gap of 1.1mm)
Spark plugs 22401-53J16 (PRF6B, SR20DET)
Crank angle sensor 23731-85M10 (CA18 all)
Crank angle sensor 23731-50F01 (SR20 all)
Coolant temp sensor 25080-89903 (S13 all)
Oil pressure sender 25240-89920 (S13 all)
Cam shaft timing belt 13028-51E25
Cam belt idler bearing 30BD219DWAX
Cam belt tenioner bearing. 35BD219DWAX
Cam cover half round bushes
NI-11051-58S00
Same as on EXA CA18, these are the half round bushes that
leak oil at the back of the head. About $7 each.
Gearbox & Clutch parts
Gear shifter spigot bush
NI-32861-H7301
Same as on most Nissan manuals, Bluebird 5 speed etc. Pops on with moderate force. About $5
Gearbox shifter oil boot (lower boot)
NI-32862-V5001
Also common to many Nissan gearboxes. Smear gearstick with silicon grease to fit it on. About $17
Clutch kit
Available locally, Standard 550kg or Heavy 800kg kits are from Adelaide Clutch Service. Daiken make the kit. The heavy kit work fine with a standard friction plate, even on high boost.
Clutch master cylinder kit
Stock 5/8 kit. Part number K7689X from Power Brakes SA. About $16
Body Parts
Door bump rubbers
01658-J7000 (Skyline R31)
Bonnet bump rubbers (large)
62840-D0100 (Skyline R31)
Suspension & Misc
Rear Dampers
( shockers )
See Nissan Dealer or Nismo
KONI. Part no. 80-401-081 sports type, off car adjustable.
Approx $315 a pair. Pedders Aust. Work well.
Dash push switch back lights Nissan Aust, have similar types
$11.00 each Dick Smith P8130, with fiddling needed or 12v lamps WT2-12 from WES Components, good fit. 65c each
Radius rod bushes 54468-35F20 (S13 all) includes bush Most suspension stores have Urathane substitutes. Need to be press fitted, use silicon grease.
Wheel nut 62840-21001 (R31 Skyline)
Brake pads See service info page.service.htm Bendix and others.
Trim panel clips
The black resetable button clips on the door and interior trim etc. BSM28 from Crash Supplies in Morphett st Adelaide, pack of 50. About $20.
Headlight globe Who cares Any brand. H4 60/55W 12V or H4 100/55W 12V the second one has 100Watt high beam.
S13 Main Handbook (English) Nissan Publication SM9E-OS13G0 $230 tax ex.
RS13 Service Manual, Main Issue (Japanese) Nissan A008009 $143 Tax Ex
SR20DET S13 Engine supplement Nissan A008011 $187 Tax Ex
SR20DET S13 Wiring supplement Nissan A108012
Exhaust manifold gasket 14036-D4200 (EXA 1.8, S13 CA18) Four separate pieces
Intake manifold gasket 14035-D5710 (CA18 all) Injector rail to cylinder head
Intake manifold gasket 14035-D5711 (CA18 all) Injector rail to intake runner
Intake manifold gasket 14035-53J10 (SR20 all)
Turbo inlet flange gasket 14415-75F10 (200SX)
or 14415-17M00 (S13 all) The Aust 200SX one fits.
Turbo outlet flange gasket 14445-26E00 (S13 all)
Engine front oil seal 13042-42L00 (CA18 all)
Engine rear oil seal 12279-18V00 (CA18 all)
Oil pan seal front 11121-01F10 (CA18 all)
Oil pan seal rear 11121-01F15 (CA18 all)
Head gasket 11044-51E00 (CA18 all)
Head gasket 11044-50F00 (SR20) until 9/92
Head gasket 11044-50F01 (SR20) from 9/92 till 7/93
Head gasket 11044-50F10 (SR20) from7/93 onwards
Engine gasket kit 10101-51E25 (CA18D) Engine rebuild gasket kits
Engine gasket kit 10101-56E25 (CA18DET)
Engine gasket kit 10101-50E25 (SR20DET)
Engine gasket kit 10101-51E26 (SR20D)
Valve grind gasket kit 11042-51E25 (CA18 all)
Valve grind gasket kit 11042-50F25 (SR20 all)
Fan belt 11720-V7301 (CA18 all) L = 855mm
Fan belt 11720-52F00 (SR20 all)
Compressor belt 11920-V7301 (CA18 all) also suits power steering pump
Compressor belt 11920-30R10 (SR20 all) also suits power steering pump
Water pump 21010-V5528 (CA18) until 8/90
Water pump 21010-V5529 (CA18) from 8/90
Water pump 21010-52F00 (SR20 all)
Thermostat 21200-V0201 (CA18 all) 82.0 C
Thermostat 21200-V0206 (CA18 all) 88.0 C
Thermostat 21200-53J00 (SR20 all)
Radiator cap 21430-01F01
Radiator hose - upper 21501-35F10 (CA18 all)
Radiator hose - lower 21503-35F00 (CA18 all)
Radiator hose - upper 21501-52F00 (SR20 all)
Radiator hose - lower 21503-52F00 (SR20 all)
Engine coolant 10120-89904 Castrol
Fuel filter 16400-F5100 (CA18 and SR20) RYCO Z202
Air Filter 16546-V0100 (same as R31 Skyline) K&N high flow reusable type P/N 33-2031-1
Spark plugs 22401-58S16 (PFR6A11, CA18) Non resistor type NGK BCP6ES11 (11 = gap of 1.1mm)
Spark plugs 22401-53J16 (PRF6B, SR20DET)
Crank angle sensor 23731-85M10 (CA18 all)
Crank angle sensor 23731-50F01 (SR20 all)
Coolant temp sensor 25080-89903 (S13 all)
Oil pressure sender 25240-89920 (S13 all)
Cam shaft timing belt 13028-51E25
Cam belt idler bearing 30BD219DWAX
Cam belt tenioner bearing. 35BD219DWAX
Cam cover half round bushes
NI-11051-58S00
Same as on EXA CA18, these are the half round bushes that
leak oil at the back of the head. About $7 each.
Gearbox & Clutch parts
Gear shifter spigot bush
NI-32861-H7301
Same as on most Nissan manuals, Bluebird 5 speed etc. Pops on with moderate force. About $5
Gearbox shifter oil boot (lower boot)
NI-32862-V5001
Also common to many Nissan gearboxes. Smear gearstick with silicon grease to fit it on. About $17
Clutch kit
Available locally, Standard 550kg or Heavy 800kg kits are from Adelaide Clutch Service. Daiken make the kit. The heavy kit work fine with a standard friction plate, even on high boost.
Clutch master cylinder kit
Stock 5/8 kit. Part number K7689X from Power Brakes SA. About $16
Body Parts
Door bump rubbers
01658-J7000 (Skyline R31)
Bonnet bump rubbers (large)
62840-D0100 (Skyline R31)
Suspension & Misc
Rear Dampers
( shockers )
See Nissan Dealer or Nismo
KONI. Part no. 80-401-081 sports type, off car adjustable.
Approx $315 a pair. Pedders Aust. Work well.
Dash push switch back lights Nissan Aust, have similar types
$11.00 each Dick Smith P8130, with fiddling needed or 12v lamps WT2-12 from WES Components, good fit. 65c each
Radius rod bushes 54468-35F20 (S13 all) includes bush Most suspension stores have Urathane substitutes. Need to be press fitted, use silicon grease.
Wheel nut 62840-21001 (R31 Skyline)
Brake pads See service info page.service.htm Bendix and others.
Trim panel clips
The black resetable button clips on the door and interior trim etc. BSM28 from Crash Supplies in Morphett st Adelaide, pack of 50. About $20.
Headlight globe Who cares Any brand. H4 60/55W 12V or H4 100/55W 12V the second one has 100Watt high beam.
S13 Main Handbook (English) Nissan Publication SM9E-OS13G0 $230 tax ex.
RS13 Service Manual, Main Issue (Japanese) Nissan A008009 $143 Tax Ex
SR20DET S13 Engine supplement Nissan A008011 $187 Tax Ex
SR20DET S13 Wiring supplement Nissan A108012